York International PM9*DH User Manual download pdf

TECHNICAL GUIDE

AFFINITY

MODELS: PM9*DH

GAS-FIRED

CONDENSING / HIGH EFFICIENCY

DOWNFLOW / HORIZONTAL

MODULATING FURNACES

NATURAL GAS

60 - 120 MBH INPUT

Due to continuous product improvement,

specifications are subject to change without notice.

Visit us on the web at www.york.com for the most

up-to-date technical information.

Additional rating information can be found at

www.gamanet.org.

EFFICIENCY

RATING

CERTIFIED

ISO 9001

Certified Quality

Management System

246808-YTG-C-0606

FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE

DESCRIPTION

These Category IV, highly efficient, compact, condensing

type furnaces are designed for residential and commercial

installations in a basement, closet, alcove, recreation room or

garage where the ambient temperature is above 32°F, or

higher. They may be either side wall or thru-roof vented using

approved plastic type combustion air and vent piping. All

units are factory assembled, wired and tested to assure

dependable and economical installation and operation.

WARRANTY

Lifetime limited warranty on both heat exchangers to the orig-

inal purchaser; a 20-year limited warranty from original instal-

lation date to subsequent purchaser.

10-year warranty on the heat exchanger in commercial appli-

cations.

5-year limited parts warranty.

FEATURES

• Modulating heating operation includes:

- Modulating gas valve

- Modulating inducer operation

• Provides increased comfort level & very quiet unit opera-

tion

• Compact, easy to install, ideal height 40" cabinet.

• Blower-off delay for cooling SEER improvement.

• Easy to connect power/control wiring.

• Built-in, high level self diagnostics with fault code display.

• Low unit amp requirement for easy replacement applica-

tion.

• Integrated control module for reliable, economical opera-

tion.

• High velocity filter available for easy field installation.

• May be installed as either two-pipe (direct vent) or single

pipe vent (using indoor combustion air)

• Top intake & vent connection allows installation in narrow

locations.

• Electronic Hot Surface Ignition saves fuel cost with

increased dependability and reliability.

• Induced combustion system with inshot main burners for

quiet, efficient operation.

• No special vent termination kit required.

• 100% shut off main gas valve for extra safety.

• PSC - four speed, direct drive motor with large, quiet

blower.

• 24V, 40 VA control transformer and blower relay supplied

for add-on cooling.

• Hi-tech tubular aluminized steel primary heat exchanger.

• Secondary (condensing) heat exchanger of 29-4C high-

grade stainless steel.

• Timed on, adjustable off blower capability for maximum

comfort.

• Independent door removal for greater durabilty and ease

of access.

• Easy access from front of unit for cleaning, maintenance or

service.

• Protection from intake, exhaust or condensate blockage.

• Insulated blower compartment for quiet operation.

• 3-way transition facilitates fresh air piping.

1 2 3 4 5 6 7 8

Summary of Contents

Page 1 - TECHNICAL GUIDE

TECHNICAL GUIDEAFFINITY MODELS: PM9*DHGAS-FIREDCONDENSING / HIGH EFFICIENCYDOWNFLOW / HORIZONTAL MODULATING FURNACESNATURAL GAS60 - 120 MBH INPUTDue t

Page 2 - DIMENSIONS

246808-YTG-C-06062 Unitary Products GroupAnnual Fuel Utilization Efficiency (AFUE) numbers are determined in accordance with DOE Test procedures.Wire

Page 3 - Unitary Products Group 3

246808-YTG-C-0606Unitary Products Group 3NOTES:1. Airflow expressed in standard cubic feet per minute (CFM) and in cubic meters per minute.2. Motor vo

Page 4 - FILTER PERFORMANCE

246808-YTG-C-06064 Unitary Products GroupFILTER PERFORMANCEThe airflow capacity data published in the “Blower Perfor-mance” table listed ab

Page 5 - Unitary Products Group 5

246808-YTG-C-0606Unitary Products Group 5For additional connection diagrams for all UPG equipment refer to “Line Voltage System Wiring” document avail

Page 6 - 6 Unitary Products Group

246808-YTG-C-06066 Unitary Products GroupTHERMOSTAT CHART - TWO STAGE ACAC20 2 Stage Scroll A/C w/Modulating Furnace, 2 Stage Cooling Ready - P(C/M)8/

Page 7 - DETERMINE SYSTEM AIRFLOW

246808-YTG-C-0606Unitary Products Group 7APPLYING FILTER PRESSURE DROP TO DETERMINE SYSTEM AIRFLOWTo determine the approximate airflow of the unit wit

Page 8 - Group Drive 73069

York International PM9*DH User Manual

Browse online or download User Manual for Water heaters & boilers York International PM9*DH. Tech Guide PM9 DH 60..

Summary of Contents

More documents for Water heaters & boilers York International PM9*DH

Comments to this Manuals

York International PM9*DH User Manual

Browse online or download User Manual for Water heaters & boilers York International PM9*DH. Tech Guide PM9 DH 60..

Summary of Contents

More documents for Water heaters & boilers York International PM9*DH

Comments to this Manuals

Related products and manuals for Water heaters & boilers York International PM9*DH